Seltos Manual
Search by Title only
Home > Maintenance > Fuses > Replacing engine compartment fuse

Replacing engine compartment fuse

1
Turn the ignition switch and all other switches off.
2
Remove the fuse panel cover by pressing the tab and pulling the cover up.
3
Check the removed fuse; replace it if it is blown. To remove or insert the fuse, use the fuse puller in the engine compartment fuse panel.
4
Push in a new fuse of the same rating, and make sure it fits tightly in the clips. If it fits loosely, we recommend that you consult a professional workshop. Kia recommends to visit an authorised Kia dealer/service partner.
CAUTION

After checking the fuse panel in the engine compartment, securely install the fuse panel cover through the audible clicking sound.

If not, electrical failures may occur from water contact.

Main fuse (Multi fuse)

If the multi fuse is blown, it must be removed as follows:

1
Turn the ignition switch and all other switches off.
2
Disconnect the negative battery cable.
3
Remove the nuts shown in the picture above.
4
Replace the fuse with a new one of the same rating.
5
Reverse these steps to reinstall the multi fuse.
NOTICE

If the multi fuse is blown, consult a professional workshop. Kia recommends to consult an authorised Kia dealer/service partner.

Driver's side fuse panel

NOTICE

Not all fuse panel descriptions in this manual may be applicable to your vehicle. It is accurate at the time of printing. When you inspect the fuse panel in your vehicle, refer to the fuse panel label on the inside of the fuse cover. This diagram will provide you with the specific information for your vehicles.

Refer to the following table for a description of the fuse.

Fuse Name

Symbol

Fuse rating

Circuit Protected

P/SEAT (DRV)

30 A

Driver Seat Manual Switch

AMP

25 A

Without ISG: AMP (Amplifier)

With ISG: DC-DC Converter Unit

P/WDW RH

25 A

Power Window Relay RH, Driver Safety Power Window Module

P/WDW LH

25 A

Power Window Relay LH, Driver Safety Power Window Module

WIPER RR

10 A

Engine Room Block (Rear Wiper Relay), Rear Wiper Motor

SEAT VENT FRT

10 A

Front Air Ventilation Seat Control Module

SUNROOF

20 A

Sunroof Unit

TAIL GATE OPEN

10 A

Tail Gate Relay

MODULE 1

7.5 A

Hazard Switch, Data Link Connector

BRAKE SWITCH

10 A

Stop Lamp Switch, IBU (Integrated Body Control Unit)

DOOR LOCK

20 A

Door Lock Relay, Door Unlock Relay

IBU1

15 A

IBU (Integrated Body Control Unit)

START

7.5 A

[Manual Transmission & Without Smart Key] Ignition Lock & Clutch Switch

[Manual Transmission & With Smart Key] Engine Room Block (Start Relay), IBU (Integrated Body Control Unit), ECM (Engine Control Module), PCM (Power train Control Module)

[Auto Transmission] Transmission Range Switch

WIPER FRT1

10 A

IBU (Integrated Body Control Unit), ECM (Engine Control Module)/PCM (Power train Control Module)

MEMORY 2

10 A

ICM (Integrated Circuit Module) Relay Box (Outside Mirror Folding/Unfolding Relay), Instrument Cluster, Air Conditioner Control Module, Security Indicator, Head-Up Display

MULTI MEDIA

15 A

Audio., Audio/Video & Navigation Head Unit

IG1

25 A

Engine Room Block (Fuse - F33, F34, F35)

ABS

10 A

ESP (Electronic Stability Program) Control Module

REAR HAETED

10 A

ECM (Engine Control Module), PCM (Power train Control Module), Air Conditioner Control Module

IBU2

7.5 A

IBU (Integrated Body Control Unit)

MODULE 5

10 A

Electro Chromic Mirror, IBU (Integrated Body Control Unit), Front Wireless Charger, Auto Transmission Shift Lever Indicator, Driver Console Switch, Audio, Audio/Video & Navigation Head Unit, Air Conditioner Control Module, Crash Pad Switch, AMP (Amplifier), Front Air Ventilation Seat Control Module

MODULE 3

7.5 A

Stop Lamp Switch, Auto Transmission Shift Lever

AIR BAG

10 A

SRS (Supplemental Restraint System) Control Module

FRT WIPER2

25 A

Engine Room Block (Wiper 1 Relay), Front Wiper Motor

MDPS*1

7.5 A

MDPS (Motor Driven Power Steering) Unit

A/BAG IND

7.5 A

Cluster

CLUSTER

7.5 A

Instrument Cluster, Head-Up Display

A/C1

7.5 A

Engine Room Block (Blower Relay), Air Conditioner Control Module

POWER OUTLET2

20 A

Front Power Outlet #1

MODULE 2

10 A

USB Charger, IBU (Integrated Body Control Unit), Audio, Surround View Monitor, Audio/Video & Navigation Head Unit, Air Purifier, AMP (Amplifier), Power Outside Mirror Switch

A/C2

10 A

Air Conditioner Control Module

MODULE 7

7.5 A

Head Lamp LH/RH, IBU (Integrated Body Control Unit), Crash Pad Switch, Front Air Ventilation Seat Control Module

WASHER

15 A

Multifunction Switch

POWER OUTLET1

15 A

Front Power Outlet #1

MODULE4

7.5 A

Eelectronic Parking Brake, ESP Switch (Electronic Stability Program Control Module), Lane Keeping Assist System Unit, Dosing Valve Control Unit, IBU (Integrated Body Control Unit), Clutch Sensor (Smartstream G1.5), Front Radar

SUNROOF2

20 A

Sunroof Unit

* 1: MDPS (Motor Driven Power Steering) is the same as EPS (Electric Power Steering).

Engine compartment fuse panel

Refer to the following table for a description of the fuse.

Fuse Name

Symbol

Fuse rating

Circuit Protected

ALT

150 A

[ALL] Alternator, Rear Defogger Relay, ESP (Electronic Stability Program) Control Module, ESP (Electronic Stability Program) Control Module, Blower Relay

180 A

[(Diesel) 1.5 VGT] Glow Relay Unit, Dosing Valve Control Unit Relay

MDPS

80 A

MDPS (Motor Driven Power Steering) Unit

GLOW

100 A

[(Diesel) 1.5 VGT] Glow Relay Unit

RR HTD

30 A

Rear Defogger Relay

ABS1

40 A

ESP (Electronic Stability Program) Control Module

ABS2

30 A

ESP (Electronic Stability Program) Control Module

BLOWER

40 A

Blower Relay

ECU4

20 A

ECM (Engine Control Module), PCM (Power train Control Module)

SENSOR 1

10 A

[ALL] Fuel Pump Relay

[(Diesel) 1.5 VGT] Inlet Metering Unit

SENSOR 2

10 A

[ALL] Air Conditioner Relay

[Smartstream G1.5 T-GDi] Purge Control Solenoid Valve, RCV, V Oil Pump, Oil Control Valve , Oxygen Sensor Up & Down

[Smartstream G1.5] Purge Control Solenoid Valve, Cooling Fan Hi Relay, Cooling Fan Lo Relay, VIS Solenoid, Oil Control Valve, Oxygen Sensor Up & Down

[(Diesel) 1.5 VGT] Fuel Heater Relay, Cam Position Sensor, Cooling Fan Hi Relay, Cooling Fan Lo Relay, Stop Lamp Switch Lambda Up & Down

DCU1

40 A

[(Diesel) 1.5 VGT] Dosing Valve Relay, Dosing Valve Control Unit

EOP

30 A

[Smartstream G1.5] Electronic Oil Pump (CVT ISG Spec only)

FULL HTR

30 A

[(Diesel) 1.5 VGT] Fuel Heater Relay

ECU1

30 A

Main Relay

E-CLUTCH1

40 A

[Smartstream G1.5 T-GDi, (Diesel) 1.5 VGT] E-Clutch Unit

E-CLUTCH2

15 A

[Smartstream G1.5 T-GDi, (Diesel) 1.5 VGT] E-Clutch Unit

ECU2

15 A

ECM (Engine Control Module), PCM (Power train Control Module)

ECU5

15 A

ECM (Engine Control Module), PCM (Power train Control Module)

TCU1

25 A

ECM (Engine Control Module), PCM (Power train Control Module), TCM (Transmission Control Module)

IG2

40 A

Start Relay, IG2 Relay, Ignition Switch

IG1

40 A

ACC Relay, IG1 Relay, Ignition Switch

B+1

60 A

ICU Junction Block (Long Term Load Auto Cut Relay, Fuse - Hazard Switch, Data Link Connector, Stop Lamp Switch, IBU (Integrated Body Control Unit))

B+2

50 A

ICU Junction Block (IPS4, IPS5, IPS6, IPS8, IPS9, IPS11, IPS12, IPS17)

B+3

60 A

ICU Junction Block (IPS1, IPS2, IPS3, IPS7, IPS10, IPS13, IPS16, IPS18, IPS20)

FUEL PUMP

20 A

Fuel Pump Relay

AMS

10 A

Battery Sensor

HORN

15 A

Horn Relay, B/A Horn Relay

A/C

10 A

Air Conditioner Relay

B+4

50 A

ICU Junction Block (Fuse - Driver Seat Manual Switch, AMP (Amplifier), Power Window Relay RH, Driver Safety Power Window Module, Power Window Relay LH, Driver Safety Power Window Module, Front Air Ventilation Seat Control Module, Sunroof Unit, Tail Gate Relay)

C/FAN

40 A

[Smartstream G1.5] Cooling Fan 2 Relay, Cooling Fan 1 Relay

C/FAN

50 A

[(Diesel) 1.5 VGT] Cooling Fan 2 Relay, Cooling Fan 1 Relay

C/FAN

80 A

[Smartstream G1.5 T-GDi] Cooling Fan Motor

ECU6

10 A

ECM (Engine Control Module), PCM (Power train Control Module)

SENSOR 4

10 A

[(Diesel) 1.5 VGT] Fuel Water Sensor, Glow Relay Unit

[Smartstream G1.5 T-GDi] CVVD Actuator

TCU2

10 A

[Smartstream G1.5 T-GDi] Inhibitor Switch (Gear Switch) [Auto Transmission], Electronic Oil Pump [Auto Transmission]

[(Diesel) 1.5 VGT] Inhibitor Switch (Gear Switch) [Auto Transmission], TCM (Transmission Control Module) [Auto Transmission]

[(Diesel) 1.5 VGT] E-Clutch Unit [Cluthless Manual]

DCU4

15 A

[(Diesel) 1.5 VGT] Dosing Valve Control Unit

DCU3

20 A

[(Diesel) 1.5 VGT] Dosing Valve Control Unit

ECU3

20 A

ECM (Engine Control Module), PCM (Power train Control Module)

INJECTOR

15 A

[Smartstream G1.5] Injector #1/#2/#3/#4

SENSOR 3

10 A

[(Diesel) 1.5 VGT] Mass Air Flow Sensor, PM Sensor, Electronic VGT (Variable Geometry Turbocharger) Actuator ,EGR Cooling Bypass Solenoid Valve

[Smartstream G1.5 T-GDi] Cooling Fan Motor

IGN COIL

20 A

Ignition Coil #1/#2/#3/#4, Condenser

DCU2

20A

[(Diesel) 1.5 VGT] Dosing Valve Control Unit

SGA

40 A

[Smartstream G1.5 T-GDi] Smart Gear Actuator

DCT1

40 A

[Smartstream G1.5 T-GDi] Transmission Control Module (TCM)

DCT2

40 A

[Smartstream G1.5 T-GDi] Transmission Control Module (TCM)

DCT3

15 A

[Smartstream G1.5 T-GDi] Transmission Control Module (TCM)

CWD1

40 A

[Smartstream G1.5 T-GDi] CWD Actuator

CWD2

15 A

[Smartstream G1.5 T-GDi] CWD Actuator

Refer to the following table for the relay type.

Relay Name

Symbol

Type

Main Relay

MINI

Start Relay

MICRO

Fuel Heater Relay

MICRO

Cooling Fan 2 Relay

MICRO

Wiper 1 Relay

MICRO

DCU Relay

MICRO

A/C Relay

MICRO

ACC Relay

MICRO

IG1 Relay

MICRO

IG2 Relay

MICRO

Cooling Fan 1 Relay

MICRO

Wiper 2 Relay

MICRO

Horn Relay

MICRO

Rear Defogger Relay

MICRO

Blower Relay

MICRO

Rear Wiper Relay

MICRO

B/A Horn Relay

MICRO

Fuel Pump Relay

MICRO